A Repeated-Dose Pharmacokinetic Evaluation of Dilaudid SR Tablets (Hydromorphone HCI) in Patients With Chronic Pain

This was an open-label, repeated-dose study involving patients who required opioid therapy on a daily basis for chronic pain conditions. In this study, baseline evaluations were performed at Visit 1. Patients were given a diary in which to record daily opioid medication use and daily pain-relief ratings throughout the study. During the time between Visit 1 and Visit 2 patients continued taking their prior oral or transdermal opioid medication for pain. Patients were considered stabilized when during usual activity, the total daily dose of baseline medication remained unchanged, with no more than three opioid breakthrough pain medication doses/day administered, for two consecutive days. Patients returned within 1 week of Visit 1 for Visit 2. During this visit, patient's 24-hour baseline oral opioid dose was converted to hydromorphone at a conversion ratio of approximately 5:1 (oral morphine sulfate to oral hydromorphone HCI mg equivalents). Patients were dispensed OROS hydromorphone HCI slow release tablets and were then increased to acceptable analgesia (pain relief). Eligible stabilized patients requiring a total daily dose of at least 8 mg but no more than 64 mg of OROS hydromorphone HCI slow release (exclusive of breakthrough medication) began the 5-10 day maintenance therapy phase at Visit 3. Morphine sulfate (immediate-release tablets) were provided as breakthrough pain medication. Patients returned to the clinic in the morning following a minimum of 4 days of continuous OROS hydromorphone HCI slow release therapy at a constant daily dose for Visit 4. Upon arrival at the clinic, an initial (trough) blood sample was taken prior to witnessed administration of the usual dosage of OROS hydromorphone HCI slow release. The exact time of the drug administration was documented. Patients were instructed to return the following morning and not to consume food or beverage within 3 hours of their scheduled visit. Patients were instructed not to self administer their OROS hydromorphone HCI slow release the following morning; they were dosed in the clinic. Patients could take immediate release morphine sulfate as needed. Patients returned to the clinic the next morning (visit 5) and remained for a 24-hour period for witnessed dosing and plasma (blood) sampling for pharmacokinetic (metabolism/action) analysis. Dosing and plasma (blood) sampling began 24 hours following the time of dosing at the clinic the previous day. Water (240 mL) was taken with the medication. Immediately prior to each blood draw, patients rated their pain intensity using an 11-point scale and rated their pain intensity from 0 (no pain) to 10 (pain as bad as you can imagine). Blood samples for analysis were drawn at: 0 (prior to dosing), 1,2,4,6,8,10,12,15,18,21 and 24 hours after dosing. Urine output was collected over the 24-hour period from selected patients. Vital signs were taken. At the conclusion of Visit 5 or in the event of early study termination, a Global Evaluation and physical examination were performed. The patient's diary was reviewed with the patient and all unused study medication was collected. Safety assessments included vital signs and physical examination at the start and end of study. OROS Hydromorphone HCL (slow release) 8,16,32,and 64 mg tablets orally. Patients were stabilized on prior opioids then converted to OROS Hydromorphone HCL (slow release) and slowly increased or decreased to adequate analgesia. Then the patients were maintained at that dose for 4 - 10 days. Duration of treatment was up to 31 days.